Alphabetical Index.

Accelerator - Cable, adjust
Accelerator - Cable, remove and install
Accelerator - Pedal lever, remove and install
Accelerator - Pedal , replace

Air bag - See SRS

Air conditioning system

	General description
	Air Conditioning - System, service
	Blower - Motor, remove and install
	Blower - Resistor, remove and install
	Blower - Switch, remove and install
	Cable - Defrost ventilation, replace
	Cable - Footwell ventilation, replace
	Cable - Fresh air flap, replace
	Cable - Mixture flap, replace
	Compressor - Remove and install
	Condenser - Remove and install
	Dash Vents - Tightening loose vents
	Evaporator - and Expansion valve, remove and install
	Evaporator - Temperature sensor, remove and install
	Housing - Heater, remove and install
	Motor - Fresh air / recirculation, replace
	Receiver drier - replace

Air flow meter - Adjusting CO
Air flow meter - Remove and install

Alternator - Bearing, replace
Alternator - Carbon brushes, replace
Alternator - Diode plate, replace
Alternator - Disassemble and assemble
Alternator - Voltage regulator, replace

Axle - Remove and Install
Axle Seal - Replace
Axle - CV Boot, replace

Baffle - Oil pan, install.

Brake lights - replace
Brake light - High mount, replace.

Brake system

	ABS - Hydraulic unit, notes
	Brakes - Bleeding or flushing
	Brake - Lines, replace
	Brake - Pedal, remove and install
	Caliper - Remove and install
	Caliper - Rebuild
	Description of the brake system
	Description - of Anti-Lock braking system
	Master cylinder - Remove and install
	Master cylinder - Rebuild
	Pads - Replace
	Park brake - Adjust
	Park brake - Lever assembly, remove and install
	Park Brake - Shoes, replace
	Rotors - Remove and install

	Bumper - Front, remove and install Bumper - Rear, remove and install
	Camshafts - Remove and install.

Carbon canister - Remove and install

Center console - Remove and install

Center Support - Replace

Central Locking System:

	Central locking - Description
	Central locking - Door actuator, remove and install
	Central locking - Fuel door actuator, remove and install
	Central locking - Trunk lid actuator, remove and install

Charging System:

	Alternator - Bearing, replace
	Alternator - Carbon brushes, replace
	Alternator - Diode plate, replace
	Alternator - Disassemble and assemble
	Alternator - Voltage regulator, replace

Check control - Remove and install
Check control - Wiring connector pin out.
Check control - Troubleshooting

Clock - Description of function
Clock - Remove and install, lights, replace

Clutch system

Troubleshooting the clutch system

	Clutch - Bleeding
	Clutch - Pedal, adjust
	Clutch - Pedal, remove and install
	Disc - Remove and install
	Master cylinder - Remove and install
	Master cylinder - Rebuild
	Release bearing - Remove and install
	Slave cylinder - Remove and install
	Slave cylinder - Rebuild

	Coding plug - General information for instrument coding
	Compression - Checking

Connecting rods - Remove and install.

Control arm - Front - Bushing, replace
Control arm - Front - Remove and install
Control Arm - Rear - Remove and install, replace bushing

Cooling System

	Cooling system - Flushing
	Cooling system - Pressure testing
	Expansion tank - Remove and install
	Radiator - Remove and install

Crankshaft

	Crankshaft - Remove and install.
	Front seal - Replace.
	Rear seal - Replace.
	Pilot bearing - Replace.

	Cruise control - Description of operation Cruise control - Installing cruise on a non cruise vehicle.
	CV Boot, replace

Cylinder head - Leak testing.
Cylinder head - Remove and install.

Diagnostic connector - Pin layout

Differential - Remove and Install

	Differential - Mount, replace
	Differential - Pinion seal, replace
	Differential - Carrier (rear sub-frame), remove and install
	Differential - Tag information
	Differential - Welding a "locker"

Distributor - Cap and Rotor, remove and install

	DME - Engine control unit, remove and install DME - Engine electronics system description
	Door - Adjust Door - Handle, Outer, remove and install Door - Hinge bushings, replace Door - Latch, remove and install Door - Lock cylinder, replace Door - Lock striker, replace Door - Panel, remove and install Door - Remove and install Door - Replace Door - Seal, outer window , remove and install Door - Stop, remove and install

Driveshaft - Bushing - Nose, replace
Driveshaft - Center Support - Replace
Driveshaft - Guibo - Replace
Driveshaft - Remove and install

	Electric fan - Remove and install
	Emblem - Model designation, replace Emblem - Roundels replace

Engine - Remove and install.
Engine - DME control unit, remove and install

Exhaust system

	Exhaust - Manifold - Remove and install
	Exhaust - System, remove and install
	Muffler - Replace

	Fan -Dual temperature switch - Wiring repair.
	Fan - Water pump - Remove and install.

	Fan clutch - Remove and install.
	Fog Lights - Remove and install
	Flywheel - Dual Mass - System description. Flywheel - Remove and install. Flywheel - Ring gear - Replace.

	Front pulley - Remove and install.
	Front seal - Replace.

Front Axle - Troubleshooting

Fuel system

	Fuel pump - Pre pump, remove and install
	Fuel pump - Main, remove and install
	Fuel tank - Remove and install
	Diagnosis - Fuel system
	Vapor tank - Remove and install
	Fuel filter - Replace
	Fuel pressure - Regulator, remove and install
	Fuel pressure - Testing

Fuse Allocation
Fuse box - Replace

Gauge - Fuel , remove and install
Gauge - Temperature, remove and install

Glove compartment - Handle, remove and install
Glove compartment - Remove and install

Grab handle - Remove and install

Grille - Center, remove and install
Grille - Headlight , remove and install
Grille - Heater air inlet, remove and install

	Guibo - Replace
	Headers - Exhaust manifold, Remove and install
	Headlight - Aim Headlight - Assembly , remove and install Headlight - Halogen bulb, replace Headlight - Sealed beam, replace

Heating system:

	General description
	Blower - Motor, remove and install
	Blower - Resistor, remove and install
	Blower - Switch, remove and install
	Cable - Defrost ventilation, replace
	Cable - Footwell ventilation, replace
	Cable - Fresh air flap, replace
	Cable - Mixture flap, replace
	Dash Vents - Tightening loose vents
	Heater - Core, remove and install
	Heater - Valve, replace
	Housing - Heater, remove and install
	Motor - Fresh air / recirculation, replace

	Hood - Adjust Hood - Latch, replace Hood - Release cable, replace
	Horn - Switch, replace

Idle - Control valve, remove and install
Idle - Speed, adjust

Ignition Coil - Check or replace

	Ignition cylinder - remove and install
	Instrument - Cluster, remove and install - Non SRS Instrument - Cluster, remove and install - SRS

Intake - Manifold gaskets, replace

Interior lights - Replace bulb, remove and install

Interior light - Delay module

Lights

	Fog Lights - Remove and install
	Headlight - Aim
	Headlight - Assembly , remove and install
	Headlight - Halogen bulb, replace
	Headlight - Sealed beam, replace
	Turn Signal - Bulb, replace
	Glove compartment - light, remove and install
	Interior lights - Replace bulb, remove and install
	Interior light - Delay module
	Rear lights - replace
	Third brake light - Replace.
	Side Markers - Remove and install
	Tail light - Assembly, remove and install

Master cylinder - Brake - Remove and install
Master cylinder - Brake - Rebuild
Master cylinder - Clutch - Remove and install
Master cylinder - Clutch - Rebuild

	Manifold - Intake gaskets, replace Manifold - Exhaust, Remove and install
	Mirror - Description of operation Mirror - External rear view, remove and install Mirror - External rear view, replace glass
	Muffler - Replace
	Multi-function clock - Remove and install

OBC - Ambient temp sensor, remove and install
OBC - Back light module, remove and install
OBC - Description of function
OBC - Remove and install
OBC - Wiring Pin out

Oil filter - Replace.
Oil pan - Lower, remove and install.
Oil pan - Baffle, install.
Oil pan - Upper, remove and install.
Oil pressure - Testing.
Oil pump - Drive chain, replace.
Oil pump - Remove, check and install
Oil - Dipstick - Tube, remove and install

	Oxygen Sensor - Description of function Oxygen sensor - Replace
	Pedal - Assembly, remove and install Pedal - Bearing sleeve, replace

Pilot bearing - Replace

Pistons

	Remove and install
	Rings - Replace

	Power steering - Pump - Remove and install Power steering - Pump - Rebuild
	Power steering - Troubleshooting
	Power steering - Fill and bleed

Radiator - Remove and install

	Radio - Anti - theft, remove and install
	Rear seal - Crankshaft, replace.
	Relays - Component location

Ride height - Front - Check and correct

Seats

	Front seat - Remove and install
	Front seat - Rail, remove and install
	Front seat - Back rest, remove and install
	Front seat - Backrest cover , remove and install
	Front seat - Height adjusting springs, replace
	Front seat - Plastic trim on outside of seat, remove and install.
	Front seat - Reclining springs, replace
	Front seat - Reclining mechanism, remove and install
	Front seat - Release cables for seat back, replace.
	Front seat - Upholstery, thigh bolster, remove and install.
	Front seat - Upholstery, seat base, remove and install.
	Rear seat - Remove and install

	Seat belt - Front, remove and install Seat belt - Rear, remove and install
	Service Indicator - Circuit board, remove and install

Shift - Knob and boot, remove and install
Shift Selector - Rod, remove and install
Shift Lever - Remove and install

	Shock absorber - Front - Replace Shock absorber - Rear - Remove and install
	Side Markers - Remove and install
	Slave cylinder - Remove and install Slave cylinder - Rebuild

Spark Plug - Wires, repair

	Speakers - Front, remove and install Speakers - Rear, remove and install
	Speedometer - Sending unit , remove and install Speedometer - Remove and install

SRS - System description
SRS - Control unit, remove and install
SRS - Crash sensor, remove and install
SRS - Slip ring, remove and install
SRS - Airbag, remove and install

Starter Motor - Operating principles
Starter Motor - Remove and Install
Starter Motor - Troubleshooting

Steering - Column - Knuckle, replace
Steering - Column - Remove and install
Steering - Column - Steering lock , replace
Steering wheel - Remove and install
Steering - Rack - Setting neutral position
Steering - Rack - Remove and install

Strut - Front - Remove and install

Sub-frame - Front Cross member - Remove and install
Sub-frame - Rear Differential Carrier, remove and install

Sunroof - Adjust
Sunroof - Cables, replace
Sunroof - Crank, remove and install
Sunroof - Drains, cleaning
Sunroof - Drive gear, manual roof, remove and install
Sunroof - Lid, remove and install
Sunroof - Liner, remove and install
Sunroof - Motor, remove and install
Sunroof - Seal, replace
Sunroof - Wind deflector, install

Sway bar - Front - Remove and install

Tie rod - Replace

Timing gear.

	Chain - Idler pulley, remove and install
	Chain - Replace.
	Gears - Replace.
	Lower cover - Remove and install.
	Tensioner - Piston, replace.
	Tensioner - Rail, upper, remove and install.

Thermostat - Replace.

	Torque Values - Engine, S14.
	Trim - B pillar, remove and install Trim - Door opening sill plates, remove and install Trim - Dashboard, remove and install Trim - Front roof lining, remove and install Trim - Panel, lower left dash, remove and install Trim - Panel, side, remove and install Trim - Parcel shelf, remove and install Trim - Rain gutter, remove and install Trim - Rear side glass, replace Trim - Trunk interior panels, remove and install
	Trunk - Common water leak points Trunk - Lock and latch, remove and install Trunk lid - Remove and install or adjust
	Turn Signal - Bulb, replace
	Transmission - Fluid - Changing Transmission - Remove and install Transmission - Seal - Output shaft, replace Transmission - Seal - Gear selector shaft, replace

	Valve cover - Remove and install. Valve guides - Check for wear. Valves - Leak check. Valves - Machining. Valves - Remove and install. Valve seals - Replace.
	Water leaks - Locations of common leaks.

	Water pump - Remove and install.
	Wheels - Remove and install / Changing a flat

Wheel bearing - Front - Replace

	Wind deflector - For sunroof, install
	Window - Door, adjust Window - Door, regulator, remove and install until 3/88 Window - Door, regulator, remove and install from 3/88 Window - Door, remove and install Window - Rear side glass, remove and install - Opening window Window - Rear side glass, remove and install - Fixed window Window - Rear side glass, replace Window seal - Door, Inner, remove and install

Windshield Wipers - Arms, Remove and install.

E30 M3 Repair Manual V2.7. Copyright �1999-2001 Koala Motorsport & Brett Anderson